Contents
How much is a throttle body for a Volvo?
Volvo S60 Throttle Body Replacement Cost Estimate. Labor costs are estimated between $115 and $145 while parts are priced between $660 and $737. This range is based on the number and age of Volvo S60’s on the road.
Why do throttle bodies go bad?
One of the main causes of a malfunctioning throttle body is internal contamination. This causes ‘false air’ to be sucked in, so that the total amount of air sucked in does not correspond to the position of the throttle valve. An incorrectly adjusted throttle position sensor can also cause an engine to run badly.
How much does it cost to fix a throttle control?
Electronic Throttle Control Repair Cost – Here’s What You Need To Know. Since this is such a key part to every car’s internal system, the average cost for this repair can be quite pricey – the average electronic throttle control repair cost comes out to around $645!
What happens when the electronic throttle control goes bad?
When a TPS goes bad, then the car’s throttle body won’t function properly. It could either stay shut or it won’t close properly which is a severe issue. When the throttle gets stuck in an open position than your vehicle will receive too much air and cause it to have a high or fluctuating idle.
What are signs of a bad throttle body?
Here are the most common signs a failing throttle body we’ve seen in our shop:
- Grime buildup. Dirt and grime can build up inside the part’s housing (some mechanics call this “coking”) causing an interruption in air-fuel flow.
- Electrical problems.
- Airflow disruptions.
- Poor or high idle.
- The ominous check engine light.
How do you know if your electronic throttle control is bad?
Rather than moving a cable, ETC uses sensors to inform the ECM of the position of the gas pedal, and when it fails, symptoms can be severe. Some of these include sudden idle surges and engine stalling, an engine light that flashes intermittently, or a massive drop in mileage.
Where are the potentiometers on a Volvo ETM?
In this mode you will experience poor engine performance, poor throttle response and the car will not exceed 40MPH. Each ETM contains two separate potentiometers located on either side of the throttle shaft in the plastic end caps.
How to repair an ETM in a Volvo?
Step 1: Purchase our repair service online or over the phone. Step 2: After processing your order, we will email you pre-paid shipping labels. Step 3: Send us your old defective unit by dropping off the package to any UPS location, or call UPS to schedule a pickup.
Which is contact less TPS sensor does Volvo use?
Contact-less programmable dual-sensor TPS upgrade: Zero wear Hall-Effect dual Throttle Position Sensor, designed and manufactured by XeMODeX. This contact-less TPS design eliminates any friction related TPS failures. XeMODeX TPS sensors are fully programmable unlike the clones out there which are pre-set and locked.