Contents
How do I know if my EGR valve is leaking?
A vacuum-controlled EGR valve is easy to test with a hand-held vacuum pump (see the image). If the EGR valve opens and the vacuum holds for more than a minute, the EGR valve works. If a vacuum diaphragm inside the EGR valve is leaking, the vacuum will drop. Once the vacuum is released, the valve should close fully.
What is EGR coolant?
The EGR cooler is a component used to lower the temperature of the exhaust gases that are recirculated by the EGR system. The EGR system recirculates exhaust gases back into the engine in order to decrease cylinder temperatures and NOx emissions.
Does EGR valve affect cooling system?
The flow of exhaust gases through the EGR cooler is controlled by the vehicle’s computer via the EGR valve. All of the heat from the exhaust system is simply transferred to the vehicle’s cooling system.
How long should an EGR cooler last?
The EGR cooler is an integral part of your vehicle that ensures your engine runs efficiently, and that you’re doing your part and not releasing as much noxious exhaust. Typically you can expect to get about 80,000 miles out of the part, but defects and damage may cause its lifespan to be shortened.
How much does it cost to fix EGR valve?
The average cost of replacing the EGR valve in your vehicle is anywhere from $250 to $350 on average, depending on your vehicle’s year, make, and model as well as the type of system it has. The cost of parts will be somewhere around $190 to $270, while the cost of labor will be anywhere from $60 to $80.
What causes EGR to fail?
The failure of the EGR valve on the vehicle is not out of the ordinary, as this issue can arise on most modern diesel engines. The failures are usually caused by a build-up of deposits in the EGR valve over a period of time that causes them to stick.
Can a EGR cooler be cleaned?
That’s a reasonable idea; EGR coolers are like radiators, only they use water to cool hot exhaust gases, instead of air to lower the hot water’s temperature. That means they can be cleaned like a radiator. If the water runs clear, that’s as good a job your liquid cleaner is going to do.
Can EGR cooler be cleaned?
How much does it cost to replace a EGR valve?
The average cost for an EGR Valve Replacement is between $314 and $399 but can vary from car to car.
Can I drive with bad EGR?
Can I drive with a bad EGR valve? Technically, you can drive your vehicle with a bad EGR valve, but your vehicle will run rough, shake at idle, and a check engine light will be illuminated. You might also hear popping sounds while driving down the road.
What are the signs of a bad EGR cooler?
Symptoms of a Bad EGR Cooler
- White smoke. When EGR cooler starts to fail, it will drain a lot of coolant out of the EGR cooler into your exhaust system.
- Missing coolant from your D gas/overflow bottle.
- Gooey EGR valve.
What happens when coolant enters the EGR system?
If the coolant is entering the EGR system, it can mix with this carbon. Small amounts of coolant can mix with this carbon, creating a sticky, tar-like buildup. In some cases, there may be enough coolant passing through to strip away the carbon. This leaves the valve looking like it has been steam cleaned.
What causes a cracked EGR cooler to overheat?
Exhaust gas pressure upstream of the turbo can be higher than coolant pressure, which means it’s possible for these gases to enter the coolant system through a cracked EGR cooler. This can push coolant out of the overflow bottle, which may lead to overheating.
What does EGR stand for in diesel engine?
EGR stands for the ‘exhaust gas recirculation’, a system that pumps exhaust back into the inlet of your engine, at times, in measured doses. Diesels do this more enthusiastically than petrols, but they both do it.
When did the VW EGR valve come out?
A 2014 model 180 van would have an earlier than D suffix EGR (which was introduced in 2016) so this may be the reason it leaked. VW should contribute something of the replacement cost of the EGR as ‘good will’, but not for the cam belt and water pump costs.